MATERIAL SAFETY DATA SHEET
CONDENSATE CONTROL
1. IDENTIFICATION OF THE PREPARATION AND THE COMPANY
PRODUCT NAME: Condensate control
APPLICATION: Corrosion Control
COMPANY IDENTIFICATON: Delaran Rooz co.
Address:Unit16,No217,St Kalhor,Ave Navab,Ave Azadi,Tehran/Iran
EMERGENCY TELEPHON NUMBER: +9821 66947449,66947491
2. COMPOSITION/ INFORMATION ON INGREDIENTS
CHEMICAL DESCRIPTION :
Hydro chloride acid : Mercaptobenzothiazole
HAZARDOUS INGREDIENTS:
CAS NO EINECS NO. CHEMICAL NAME WT% SYMBOL R- PHRASES
124-68-5 204-709-8 aminopropanol 10-20 C 34
3. HAZARDS IDENTIFICATION
HUMAN HEALTH HAZARDS - ACUTE:
INHALATION:
Remove Patient to fresh air.
SKIN CONTACT:
Can cause irritation and inflamation. May cause sensitization by skin contact.
EYE CONTACT:
Can cause irritation . May cause permanent damage to eyes.
INGESTION:
There may be irritation to the gastro- intestinal tract with nausea and vomiting.
HUMAN HEALTH HAZARDS- CHRONIC:
May cause sensitization by skin contact.
ENVIRONMENTAL HAZARDS
None known.
PYSICAL AND CHEMICAL HAZARDS:
None known .
4. FIRST-AID MEASURE
INHALATION:
Remove to fresh air, rest; treat symptomatically .obtain medical attention immediately
SKIN CONTACT:
Brush off excess powder. Remove contaminated clothing . wash off affected are immediately with plenty of water .obtain medical attention immediately.
EYE CONTACT:
Brush off excess powder. immediately gently irrigate with clean water for at least 15minutes. Move eyeball and keep eyelids wide open and apart whilst irrigating. obtainmedical attention immediately.
INGESTION:
If conscious washout mouth and give one pint of water to drink.Do not induce vomiting without medical advice. obtain medical attention.
5. FIRE-FIGHTING MEASURES
EXTINGUISHING MEDIA :
Not expected to burn. Use extinguishing media appropriate for surrounding fire.
UNSUITABLE EXTINGUISHING MEDIA:
Not applicable.
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE FIGHTING:
In case of fire, wear a full face positive- pressure self contained breathing apparatus and protective suit.
6. ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS :
Use personal protective equipment recommended in section8.
ENVIRONMENTAL PRECAUTIONS:
Do not allow to enter sewers or water courses. if spillage does enter sewers or water courses, immediately inform the appropriate water authorities.
METHODS FOR CLEANING UP
Clean up promptly by scoop or vacuum. Reclaim into recovery or salvage drums. clean contaminated surfaces with water or aqueous cleaning agents.
7. HANDLING AND STORAGE
HANDLING:
Avoid contact with skin and eyes. Do not breathe . if clothing is contaminated. remove clothing and thoroughly wash the affected area.Launder contaminated clothingbefore reuse. Handle with a scoop.
STORAGE CONDITIONS:
Keep container tightly closed and dry. store separately from bases. store separately from oxidizers . storage for more than two years is not recommended. Keep away of ignition.
CONSTRUCTION MATERIAL COMPATIBILITY. Compatible with:
Equipment for storage and application should be constructed from polypropylene. polyethylene. PVC, acrylic resin or polyvinylidene difuoride.
8. PHYSICAL AND CHEMICAL PROPERTIES
NOTE: These physical properties are typical values for this product
FORM : Liquid
COLOUR: clear
ODOUR : Aminelike.
VALUE UNIT TEST METHO
MELTING POINT : NA
FLASH POINT : NA
AUTOFLAMMABILITY: NA
EXPLOSION LIMITS NA
VAPOUR PRESURE: NE
RELATIVE DENSITY: 0/98
SOLUBILITY IN WATER: soluble
pH (1%) 11
OCTANOL/ WATER COEFFICIENT : NA
VISCOSITY NA
FREEZING POINT : NA
POUR POINT : NA
Abbreviation> NE= not evaluated , NA= not applicable, NR= not relevant
9. STABILITY AND REACTIVITY
STABILITY:
Stable under ambient conditions .
CONDITION TO AVOID:
Moisture . strongly acidic concentrated solutions should not be heated in closed poorly vented vessels as exothermic hydrolysis could generate sufficient steam tocause container rupture. There is no danger of runaway hydrolysis at temperaturesobtainable at atmospheric pressure . Hydrogen gas may be formed during acidcleaning . provide suitable venting when cleaning closed systems and keep flamesaway from the vent during and immediately after cleaning.
MATERIALS TO AVOID:
Aluminium, zinc
HAZARDOUS DECOMPOSITION PRODUCTS :
Nitrogen, carbon dioxide (in fire)
10. TOXICOLOGICAL INFORMATION
LD 50: > 10/000 mg/ kg
PRIMARY ( DRAIZE TEST ) SKIN / EYE
No data availabl
SENSITIZATION:
No data available
12. ECOLOGICAL INFORMATION
PERSISTENCY AND DEGRADATION:
No data available
MOBILITY AND BIOACCUMULATION POTENTIAL:
No data available
13. DISPOSALCONSIDERATION
Should be disposed of in a safe way.
14. TRANSPORT INFORMATION
Class : 8 packing Group :ll1
UN NO:2967
Proper shipping name: hydrochloride acid
ADR/ RID, H,I.N.: 80
ADR/ RID.NO: 16(C)
IMDG page 8229
EMS- Nr.: 8-08
MFAG- Nr.: 7
15. REGULATORY INFORMATION
EC CLASSIFICATION:
HAZARD SYMBOL : C CORROSIVE
16. OTHER INFORMATION
