MATERIAL SAFETY DATA SHEET
SEA CARE O.S.D (CLEANER 555)
1. IDENTIFICATION OF THE PREPARATION AND THE COMPANY
PRODUCT NAME: Cleaner 555
APPLICATION: Oil spill dispersant
COMPANY IDENTIFICATON: Delaran Rooz co.
Address:Unit 16,No217,St Kalhor,Ave Navab,Ave Azadi,Tehran/Iran
EMERGENCY TELEPHON NUMBER: +9821 66947522& 66947449
2. COMPOSITION/ INFORMATION ON INGREDIENTS
CHEMICAL DESCRIPTION:
Hydrocarbon solvent , surfactant (s), emulsifiers.
HAZARDOUS INGREDIENTS:
CAS NO. EINECS NO . CHEMICAL NAME WT% SYMBOL R- PHRASES
64742-47-8 265-149-8 Aliphatic hydrocarbon 60 -80 Xn 65
3. HAZARDS IDENTIFICATION
HUMAN HEALTH HAZARDS - ACUTE:
INHALATION:
May cause imitation of mucous membranes. May cause headache and dizziness. Components of the product may affect the nervous system.
SKIN CONTACT:
Can cause mild irritation.
EYE CONTACT:
Can cause mild irritation
INGESTION:
Harmful: may cause lung damage if swallowed. There may be irritation to the gastro - intestinal tract with nausea and vomiting. Can cause chemical pneumonia if aspirated into lungs following ingestion.
ENVIRONMENTAL HAZARDS:
None known.
PHYSICAL AND CHEMICAL HAZARDS:
FLASH PHOINT > 70 0C
4. FIRST-AID MEASURE
INHALATION:
Remove to fresh air , rest, treat symptomatically . Obtain medical attention.
EYE CONTACT:
immediately gently irrigate with clean water for at least 15 minutes. move eyeball and keep eyelids wide open and apart whilst irrigating. obtain medical attention immediately
INGESTION:
Do not induce vomiting: Contains petroleum distillates and/or aromatic solvents. If conscious washout mouth and give one pint of water to drink. Obtain medical attention.
ADDITIONAL INFORMATION:
If unconscious do not give anything by mouth, place in the recovery position, check breathing and pulse. If necessary give artificial respiration.
5. FIRE-FIGHTING MEASURES
EXTINGUISHING MEDIA:
Water spray, foam, dry powder , carbon dioxide.
UNSUITABLE EXTINGUISHING MEDIA:
Do not use water jets.
FIRE AND EXPLOSION HAZARD:
Oxides of carbon (under fire conditions)
SPECIAL PROTECTIVE EQUIPMENT FOR FIRE FIGHTING:
In case of fire, wear a full face positive - pressure self contained breathing apparatus and protective suit. Water mist may be used to cool closed containers.
6. ACCIDENTAL RELEASE MEASURES
PERSONAL PRECAUTIONS :
Remove sources of ignition. Ensure adequate ventilation. Wear organic vapours respirator if ventilation is inadequate. Wear chemical resistant apron, chemical splash goggles, impervious gloves and Wellington boots.
METHODS FOR CLEANING UP:
Contain and absorb with sand or vermiculite and mix well. Collect up and remove to a safe place until disposal. Wash site of spillage thoroughly with water and detergent. Assistance can obtained from waste disposal companies.
7. HANDLING AND STORAGE
HANDLING:
Avoid contact with skin and eyes. If clothing is contaminated, remove clothing and thoroughly wash the affected area. Launder contaminated clothing before reuse. Ensure adequate ventilation, No smoking. Avoid use of rubber.
STORAGE CONDITIONS:
Keep container tightly closed in a cool, well- ventilated place. Connections must be grounded to avoid electrical charges. Store away from heat and sources of ignition. store separately from oxidizers. Storage for more than two years is not recommended.
8. EXPOSIN CONTROL/PERSONAL PROTECTION
OCCUPATIONAL EXPOSURE LIMITS
NATIONAL REGULATIONS UK
Aliphatic hydrocarbon: manufacturers recommendation 300 ppm
ENGINEERING MEASURES:
Local exhaust ventilation if necessary to control airborne levels below the exposure guidelines.
RESPIRATORY PROTECTION:
An approved respirator must be worn if the occupational exposure limit is likely to be exceeded.
Wear organic vapour/mist respirator when spraying.
HAND PROTECTION:
Viton gloves, nitrile cloves.
SKIN PROTECTION:
Not normally needed. Wear impervious apron (if skin contact is likely).
EYE PROTECTION:
Chemical splash goggles.
HYGIENE RECOMMENDATIONS:
Keep an eye wash fountain available.
9. PHYSICAL AND CHEMICAL PROPERTIES
NOTE: These physical properties are typical values for this product.
FORM: Liquid
COLOUR: Yellow
ODOUR: Hydrocarbon
BOILING POINT: 195 (IBM)
MELTING POINT: NA
FLASH POINT: >70 C
Ignition flammability: 225C
Flammability limit lower % 0.6
Flammability limit upper % 8
RELATIVE DENSITY 0.8 (20 C)
SOLUBILITY IN WARE: Emulsifiers
PH: NE
OCTANOL/WATER COEFICIENT: NE
VISCOSITY NA
BULK DENSITY NE
FREEZING POINT: NE
POUR POINT: NE
Abbreviation NE = not evaluated, NA = not applicable, NR = not relevant
10. STABILITY AND REACTIVITY
STABILITY:
Stable under ambient conditions .
CONDITION TO AVOID:
Heat and sources of ignition including static discharges.
MATERIALS TO AVOID
Oxidizing agents.
HAZARDOUS DECOMPOSITION PRODUCTS:
Oxides of carbon (under fire conditions).
11. TOXICOLOGICAL INFORMATION
ACUTE TOXICITY DATA:
ACUTE LETHALITY VALUES:
No data available.
PRIMARY (DRAIZE TEST) SKIN/EYE
No data available.
SENSITIZATION:
No data available.
CHRONIC TOXICITY DATA:
No data available.
12. ECOLOGICAL INFORMATION
PERSISTENCY AND DEGRADATION:
No data available.
MOBILITY AND BIOACCUMULATION POTENTIAL:
No data available.
ECOTOXICOLOGICAL EFFECTS:
No data available.
13. DISPOSALCONSIDERATION
Via authorized contractor.
NATIONAL REGULATIONS UK
Complete incineration. In accordance with the Environmental Protection (Duty of care) Regulations 1991.
14. TRANSPORT INFORMATION
Class: Not regulated
15. REGULATORY INFORMATION
EC CLASSIFICATION:
HAZARD SYMBOL: Xn, HARMFUL
Xn, HARMFUL
Contains: Aliphatic hydrocarbon
RISK PHRASES:
R65 harmful: May cause lung damage if swallowed.
SAFETY PHRASES:
S62 if swallowed , do not induce vomiting: seek medical advice
Immediately and show this container or label.
S16 keep away from sources of ignition – No smoking .
S23 Do not breathe vapour .
S26 In case of contact with eyes, fines immediately with plenty of water and seek medical advice.
