MATERIAL SAFETY DATA SHEET

SEA CARE O.S.D (CLEANER 555)

 

PRODUCT NAME:                                                Cleaner 555

APPLICATION:                                                    Oil spill dispersant

COMPANY IDENTIFICATON:                          Delaran Rooz co.

   Address:Unit 16,No217,St Kalhor,Ave Navab,Ave Azadi,Tehran/Iran             

    EMERGENCY TELEPHON NUMBER:            +9821 66947522& 66947449

CHEMICAL DESCRIPTION:

Hydrocarbon  solvent , surfactant (s), emulsifiers.

           HAZARDOUS INGREDIENTS:

CAS NO.              EINECS  NO .    CHEMICAL NAME            WT%         SYMBOL        R- PHRASES

          64742-47-8      265-149-8          Aliphatic  hydrocarbon        60 -80           Xn                     65

  

HUMAN HEALTH HAZARDS - ACUTE:

INHALATION:

May cause imitation of mucous membranes. May cause headache and dizziness.  Components of the product may affect the nervous system.

SKIN CONTACT:

Can cause mild irritation.

EYE CONTACT:

Can cause mild irritation

INGESTION:

Harmful: may cause lung damage if swallowed. There may be irritation to   the   gastro - intestinal tract with nausea and vomiting. Can cause chemical pneumonia if aspirated into lungs following ingestion.

                                                                                                                                                                          

ENVIRONMENTAL   HAZARDS:

None known.                      

PHYSICAL AND CHEMICAL HAZARDS:

FLASH PHOINT > 70 ⁰C

INHALATION:

Remove to  fresh  air , rest, treat symptomatically . Obtain medical attention.

EYE CONTACT:

immediately  gently  irrigate with clean water for at least 15 minutes. move eyeball and keep eyelids wide open and apart whilst irrigating. obtain medical attention  immediately

INGESTION:

Do not induce vomiting: Contains petroleum distillates and/or aromatic solvents.                                       If conscious washout mouth and give one pint of water to drink. Obtain medical attention.

ADDITIONAL  INFORMATION:

If unconscious do not give anything by mouth, place in the recovery position, check breathing and pulse. If necessary give artificial respiration.

EXTINGUISHING MEDIA:

Water spray, foam, dry powder , carbon dioxide.

UNSUITABLE  EXTINGUISHING MEDIA:

Do not use water jets.

FIRE AND EXPLOSION HAZARD:

Oxides of carbon (under fire conditions)

SPECIAL  PROTECTIVE  EQUIPMENT  FOR FIRE  FIGHTING:

In case of fire, wear a full face positive - pressure  self  contained breathing  apparatus   and protective  suit. Water  mist may be  used to cool closed containers.

PERSONAL  PRECAUTIONS :

Remove  sources  of ignition.  Ensure adequate ventilation. Wear organic vapours respirator if  ventilation is  inadequate. Wear chemical resistant apron, chemical splash goggles, impervious gloves and Wellington boots.

                                                                                                                                                                  

METHODS  FOR  CLEANING  UP:

Contain and absorb with sand or vermiculite and mix well. Collect up and remove to a safe place   until disposal. Wash site of spillage thoroughly with water and detergent. Assistance can obtained   from waste disposal companies.

HANDLING:

Avoid contact with skin and eyes. If clothing is contaminated, remove clothing and thoroughly wash the affected area. Launder contaminated clothing before reuse. Ensure adequate ventilation, No smoking. Avoid use of rubber.

STORAGE CONDITIONS:

Keep container tightly closed in a cool, well- ventilated place. Connections must be grounded to avoid electrical charges. Store away from heat and sources of ignition. store separately  from  oxidizers. Storage for more than two years is not recommended.

OCCUPATIONAL   EXPOSURE  LIMITS

NATIONAL  REGULATIONS  UK

Aliphatic hydrocarbon:  manufacturers  recommendation  300 ppm

ENGINEERING MEASURES:

Local  exhaust ventilation  if necessary to control airborne  levels below the exposure guidelines.

RESPIRATORY  PROTECTION:

An approved respirator must be worn if the occupational exposure limit is likely to be exceeded.

Wear organic vapour/mist respirator when spraying.

HAND PROTECTION:

Viton gloves, nitrile cloves.

SKIN PROTECTION:

Not normally needed. Wear impervious apron (if skin contact is likely).

EYE PROTECTION:

Chemical splash goggles.

HYGIENE RECOMMENDATIONS:

Keep an eye wash fountain available.

                                 

NOTE:  These physical properties are typical values for this product.

FORM:                                                                   Liquid 

COLOUR:                                                              Yellow

ODOUR:                                                                Hydrocarbon

BOILING POINT:                                                  195 (IBM)

MELTING POINT:                                                NA

FLASH POINT:                                                     >70 C

Ignition flammability:                                            225C 

Flammability limit lower %                                    0.6                                                                              

Flammability limit upper %                                    8

RELATIVE DENSITY                                            0.8 (20 C)

SOLUBILITY IN WARE:                                       Emulsifiers

PH:                                                                         NE

OCTANOL/WATER COEFICIENT:                             NE

VISCOSITY                                                                  NA                                                                          

BULK DENSITY                                                          NE

FREEZING POINT:                                                      NE

POUR POINT:                                                              NE

Abbreviation    NE = not evaluated, NA = not applicable, NR = not relevant

 

STABILITY:

Stable under  ambient  conditions .

CONDITION TO AVOID:

Heat and sources of ignition including static discharges.

MATERIALS TO AVOID

Oxidizing agents.

HAZARDOUS   DECOMPOSITION PRODUCTS:

Oxides of carbon (under fire conditions).

                                                                                                                                                                                                                

ACUTE TOXICITY DATA:

ACUTE LETHALITY VALUES:

No data available.

PRIMARY (DRAIZE TEST) SKIN/EYE

No data available.

SENSITIZATION:

No data available.

CHRONIC TOXICITY DATA:

No data available.

PERSISTENCY AND DEGRADATION:

No data available.

MOBILITY   AND    BIOACCUMULATION    POTENTIAL:

No data available.

ECOTOXICOLOGICAL EFFECTS:

No data available.

Via authorized   contractor.

NATIONAL   REGULATIONS UK

Complete incineration. In accordance with the Environmental Protection (Duty of care) Regulations 1991.

     Class:                                       Not regulated

 EC   CLASSIFICATION:

  HAZARD SYMBOL:     Xn, HARMFUL

 

 

 

 

 

Xn, HARMFUL

          Contains:                      Aliphatic hydrocarbon

          RISK PHRASES:

          R65 harmful: May cause lung damage if swallowed.

         SAFETY PHRASES:

S62  if  swallowed , do not  induce  vomiting:  seek  medical  advice

Immediately  and show this  container  or label.

S16  keep  away  from  sources  of  ignition – No  smoking .

S23  Do not  breathe  vapour .

S26  In  case  of contact with eyes, fines immediately with plenty of water and seek medical advice.