m.s.d.s

PRODUCT NAME: Electroclean

COMPANY IDENTIFICATON: Delaran Rooz co.

EMERGENCY TELEPHON NUMBER:+9821 66947522 ,66948831

 

CHEMICAL    DESCRIPTION:

Glycol  ether  hydrocarbon  solvent.

HAZARDOUS   INGREDIENTS:

CAS NO.     EINECS NO.       CHEMICAL NAME           WT%     SYMBOL    R- PHRASES

90622-58-5    2924606            Aliphatic  hydrocarbon          80-100       Xn                65

34590- 94-8   2521042            Dipropylene glycol                 l 1-20       Non                Non

 

  HUMAN HEALTH HAZARDS - ACUTE:

INHALATION:

May  cause  irritation of  mucous  membranes. May cause  headache  and dizziness. Components of the product may affect the nervous system.

SKIN  CONTACT:

Can  cause  mild irritation.

EYE  CONTACT:

Can  cause  mild  irritation.

INGESTION:

Harmful: may cause lung damage if swallowed. There may be irritation to the gastro- intestinal tract with nausea and   vomiting. van cause chemical  pneumonia  if  aspirated into  lungs  following  ingestion.

HUMAN  HEALTH  HAZARDS - CHRONIC:

Prolonged/frequent skin contact may cause dermatitis. Liver injury may occur. Kidney injury  may  occur.

ENVIRONMENTAL  HAZARDS:

None   known.

PHYSICAL  AND CHEMICAL  HAZARDS:

FLASH 62ْC.

 

INHALATION:

Remove to fresh air, rest; treat symptomatically. Obtain medical attention immediately

SKIN CONTACT:

Remove  contaminated  clothing . wash  off  affected  area   immediately with  soap  and plenty of water

EYE  CONTACT:

Immediately  gently  irrigate  with clean  water  for at least 15   minutes. Move eyeball  and  keep  eyelids wide  open and apart  whilst irrigating. obtain  medical  attention  immediately.

INGESTION:

Do not induce vomiting: contains  petroleum  distillates and/or aromatic solvents. If conscious washout  mouth and give one pint of water to drink. Obtain  medical  attention immediately

EXTINGUISHING  MEDIA :

Water  spray, foam , dry powder, carbon  dioxide

UNSUITABLE  EXTINGUISHING  MEDIA:

Do  not  use  water  jets.

FIRE  AND  EXPLOSION  HAZARD

Oxides  of carbon.

SPECIAL  PROTECTIVE  EQUIPMENT  FOR  FIRE  FIGHTING:

In case of fire, wear a full face  positive- pressure self contained breathing  apparatus  and protective  suit.

 

PERSONAL  PRECAUTIONS:

Remove sources of ignition. Ensure adequate ventilation. Avoid contact with skin and eyes. In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. After contact with skin wash immediately with plenty of soap and water. Use personal protective equipment recommended in section8.      

ENVIRONMENTAL  PRECAUTIONS:

Do  not  allow to enter sewers or  water courses. If spillage   does   enter sewers  or  water   courses,  immediately  inform  the  appropriate water authorities.

METHODS  FOR  CLEANING UP:

Contain  and absorb with sand  or  vermiculite   and  mix well. Collect up and remove to a safe place until disposal. Wash  site  of  spillage thoroughly with  water  and  detergent.  Assistance can  be obtained from  waste  disposal  companies.

 

HANDLING:

Avoid  contact  with  skin and eyes. If  clothing  is  contaminated,  remove clothing  and thoroughly  wash  the affected  area. Launder  contaminated clothing before reuse. Ensure adequate ventilation. Do  not use in confined spaces.  No smoking.

Dip cleaning- Keep tanks covered.

Wiping/Brushing- Used  clothes and brushes  should  be stored  in  lidded containers.

Spraying- Spraying  can  lead  to  high   solvent vapour concentrations. Wear  organic  vapour/mist   respirator   when   spray  cleaning   large areas or if spray  cleaning for an appreciable length of time.

STORAGE  CONDITIONS:

Keep   container  tightly  closed  in a  cool,  well - ventilated   place.  Store away  from  heat  and sources of ignition. connections  must be grounded to avoid  electrical  charges.  Store  separately  from oxidizers. Equipment for storage  and application  should  be constructed from stainless steel carbon steel,  brass, cast iron or  polyethylene. Avoid use of   ethylene propylene  rubber, butyl  rubber  and  natural  rubber.

 

OCCUPATIONAL   EXPOSURE  LIMITS

NATIONAL REGULATIONS  UK

Aliphatic  hydrocarbon: Manufacturers Recommendation 300 ppm (TWA)

Dipropylene glycol  monomethyl  ether: 100 ppm (8hr TWA), 150ppm (10 mins  STEL )

ENGINEERING   MEASURES

Local  exhaust  ventilation  if  necessary to control  airborne levels  below the  exposure  guidelines.

RESPIRATOR    PROTECTION:

Wear  organic  vapour  respirator  if ventilation is  inadequate.

HAND  PROTECTION:

Neoprene gloves   or Nitrile gloves.

SKIN  PROTECTION:

Wear   impervious  apron  (if skin contact is  likely).

EYE  PROTECTION:

Chemical  splash  goggles.

HYGIENE   RECOMMENDATIONS:

Keep  an eye  wash  fountain  available.

                          

FORM:                                                        Liquid

COLOUR:                                                   Cear  colourless

ODOUR:                                                     Hydrocarbon

                                                                   VALUE          UNIT     TEST  METHOD

BOILING  POINT:                                       NE

MELTING  POINT:                                     NA

FLASH  POINT:                                          62                     ْ C            SETA

AUTOFLAMMABILITY:                             NE

EXPLOSION  LIMITS:                                 NE

VAPOUR  PRESSURE                                 NE

RELATIVE  DENSITY :                              @ 25ْ C 0.782

SOLUBILITY IN WATER:                          Insoluble

pH                                                                           NA

OCTANOL/ WATER  COEFFICIENT:         NE

VISCOSITY       @22ْ C                             3                     cps

BULK  DENSITY:                                       NE

FREEZING  POINT:                                    NE

POUR  POINT:                                            NE

Abbreviation: NE=not evaluated, NA= not  applicable, NR= not relevant

 

STABILITY:

Stable under  ambient  conditions .

CONDITION TO AVOID:

Heat and source of ignition including static discharge.

MATERIALS TO  AVOID:

Strong  oxidizing agents.

HAZARDOUS  DECOMPOSITION  PRODUCTS:

Oxides  of carbon (under  fire  conditions).

                                                                                                                                                                                                          

No data available on the product.

 

No data available on the product.

 

Via  authorized  contractor.

NATIONAL  REGULATIONS  UK

Complete incineration. In accordance with the Environmental protection (Duty of care)Regulations 1991.

 

Class:                                                                              not   regulated

 

EC  CLASSIFICATION:

HAZARD  SYMBOL:          HARMFUL

 

Xn, HARMFUL

Contains:  Aliphatic hydrocarbon

RISK  PHRASES:

R65 Harmful:  may  cause lung  damage  if swallowed

SAFETY   PHRASES:

S26 swallowed, do not induce  vomiting :seek medical  advice immediately  and  show  this  container  or  label.. S16  keep away from sources  of ignition- No  smoking. S23 Do not breathe vapour. S26 In case  of  contact  with eyes, rinse  immediately  with plenty of water and seek  medical  advice. S37/39 Wear suitable  gloves and eye/face protection.

NATIONAL   REGULATIONS  UK

COSHH regulations  apply. A precaution  card  is  available and should be  displayed  wherever  this product  is used and stored (REF.ASP).